5121-S.E AMH AG H2647.1

5121-S.E AMH AG H2647.1

ESSB 5121 - H COMM AMD NOT ADOPTED 4/12/95

By Committee on Agriculture & Ecology

Strike everything after the enacting clause and insert the following:

"NEW SECTION. Sec. 1. A new section is added to chapter 49.17 RCW to read as follows:

The safety and health standards that apply under this chapter for the agricultural industry shall consist of the safety standards for agriculture, including the exemptions for the agricultural industry from other safety and health standards under this chapter, that were in effect as of January 1, 1993, as modified by the following provisions:

(1) WAC 296-306-060 (regarding personal protective equipment) as filed March 5, 1993, and published in WSR 93-07-012.

(2) WAC 296-306-400 and 296-306-40003 (regarding pesticide posting and records) as filed March 5, 1993, and published in WSR 93-07-012.

(3) WAC 296-306-120 (1) through (10), (11)(a), and (12) (aerial manlift equipment), as filed October 19, 1994, and published in WSR 94-21-099.

(4) WAC 296-306-165 (general requirements for all agricultural equipment), as filed March 5, 1993, and published in WSR 93-07-012.

(5) WAC 296-306-170 (auger conveying equipment), as filed October 19, 1994, and published in WSR 94-21-099.

(6) WAC 296-306-08503 (general requirements for fire extinguishers), as filed October 19, 1994, and published in WSR 94-21-099.

(7) WAC 296-306-08507 (inspection, maintenance, and testing of fire extinguishers), as filed October 19, 1994, and published in WSR 94-21-099.

(8) WAC 296-306-14501 to 296-306-14511 (regarding electrical protection) as filed February 28, 1994, (as emergency rules), and published in WSR 94-06-044.

(9) WAC 296-306-061 to 296-306-06109 (regarding machine guarding) as filed September 1, 1994, and published in WSR 94-18-067.

(10) WAC 296-306-090 (storage and handling of anhydrous ammonia), as filed October 19, 1994, and published in WSR 94-21-099.

(11) WAC 296-306-09001(2) (liquefied petroleum gases installations), as filed October 19, 1994, and published in WSR 94-21-099.

(12) The following additional requirements shall apply:

(a) Hazardous materials must be stored in containers designed for such storage and must be labelled according to WAC 296-62-05411. Each employer must determine that compressed gas cylinders under his or her control are in a safe condition to the extent that this can be determined by visual inspection.

(b) Agricultural equipment employing open flames or equipment with integral containers, such as flame cultivators, weed burners, and in addition, tractors, shall be shut down during refueling.

(c) The employee or any part of agricultural aerial manlift equipment shall not come within a radius of ten feet from energized high voltage conductors, or into any part of the zone any distance above such a radius (see WAC 296-306-14511, as in effect on March 1, 1994).

(d)(i) To insure safety and serviceability the following precautions on the care of ladders shall be observed:

(A) Ladders shall be maintained in good condition at all times. Joints between steps and side rails shall be tight. All hardware and fittings shall be securely attached, and the moveable parts shall operate freely without binding or undue play.

(B) Ladders shall be inspected prior to being used. Ladders which have developed defects shall be withdrawn from service for repair or destruction and tagged or marked as "dangerous, do not use."

(C) Complete ladder inspection shall be periodical. If a ladder is involved in any of the following, immediate inspection is necessary:

(I) If ladders tip over, inspect ladder for side rails dents or bends, or excessively dented rungs; check all rung-to-side-rail connections; check hardware connections; check rivets for shear.

(II) If ladders are exposed to excessive heat as in the case of fire, the ladder should be inspected visually for damage and tested for deflection and strength characteristics. In doubtful cases, refer to manufacturer.

(D) Ladders shall be stored in a manner designed to protect ladders when not in use.

(E) Ropes or cables shall be inspected frequently and replaced if defective.

(ii) The following safety precautions shall be observed in connection with the use of ladders:

(A) Orchard ladders longer than sixteen feet shall not be used.

(B) Ladders shall be handled with care and not subject to unnecessary dropping, jarring, or misuse. Ladders are designed for a specific purpose or use; therefore, any variation from this use constitutes a mishandling of the equipment.

(D) Rungs shall be kept reasonably free of any substance which would make them hazardous.

(E) Ladders carried on vehicles should be adequately supported to avoid sagging and securely fastened in position to minimize chafing and the effects of road shocks.

(F) Portable ladders shall be so placed that the side rails have a secure footing. The top rest for portable rung and cleat ladders shall be reasonably rigid and shall have ample strength to support the applied load.

(G) Ladders shall not be placed in front of doors opening toward the ladder unless the door is blocked open, locked, or guarded.

(H) Ladders shall not be placed on boxes, barrels, or other unstable bases to obtain additional height.

(I) Ladders with broken or missing steps, rungs, or cleats, broken side rails, or other faulty equipment shall not be used; improvised repairs shall not be made.

(J) Ladders made by fastening cleats across a single rail shall not be used.

(K) Stepladders shall not be used as single ladders.

(L) When working from a ladder over twenty-five feet from the ground or floor, the ladder shall be secured at both top and bottom.

(M) No type of work shall be performed on a ladder over twenty-five feet from the ground or floor that requires the use of both hands to perform the work, unless a safety belt is worn and the safety lanyard is secured to the ladder.

(N) The ladder base section must be placed with a secure footing. Safety feet of good substantial design should be installed on all ladders except orchard ladders. Where ladders with no safety shoes or spikes are used on hard, slick surfaces, a foot-ladder board should be employed.

(iii) Training and instruction on the use of ladders:

(A) At the beginning of employment, employers shall provide employees with orientation and training on the proper use of ladders including how to set a ladder and properly dismount with a full load.

(B) Employers shall instruct employees to not stand on the top two steps (the top cap and the next step down) of the ladder.

(C) Employers shall instruct employees to not step off the ladder onto branches of trees except onto the main crotch of the tree.

(D) Employers shall instruct employees to not overreach while standing on the ladder to prevent ladder upset.

(E) Employers shall instruct employees that before climbing ladders, shoes and/or boots shall be free and clean of greasy or slippery substances.

This section does not limit the authority of the director to adopt rules that are specifically required by federal law, and only to the extent specifically required, for the standards in this section to be as effective as the standards adopted or recognized by the United States secretary of labor under the authority of the occupational safety and health act of 1970 (Public Law 91-596; 84 Stat. 1590).

Sec. 2. RCW 49.17.060 and 1973 c 80 s 6 are each amended to read as follows:

Each employer:

(1) Shall furnish to each of his employees a place of employment free from recognized hazards that are causing or likely to cause serious injury or death to his employees: PROVIDED, That no citation or order assessing a penalty shall be issued to any employer solely under the authority of this subsection except where no applicable rule or regulation has been adopted by the department covering the unsafe or unhealthful condition of employment at the work place; and

(2) Shall comply with the rules, regulations, and orders ((~~promulgated~~)) adopted under this chapter, or, in the case of agricultural employers, comply with section 1 of this act and rules adopted under section 1 of this act.

NEW SECTION. Sec. 3. A new section is added to chapter 17.21 RCW to read as follows:

(1) The director shall exercise the authority granted by RCW 17.21.030 to adopt as rules the worker protection standard for agricultural workers and handlers of agricultural pesticides adopted by the United States environmental protection agency in 40 C.F.R., part 170, as it exists on the effective date of this act.

(2) Subsection (1) of this section does not limit in any manner the authority of the director to adopt rules under RCW 17.21.030 including, but not limited to, rules amending the rules adopted under subsection (1) of this section.

NEW SECTION. Sec. 4. This act is necessary for the immediate preservation of the public peace, health, or safety, or support of the state government and its existing public institutions, and shall take effect immediately."

ESSB 5121 - H COMM AMD

By Committee on Agriculture & Ecology

On page 1, line 1 of the title, after "standards;" strike the remainder of the title and insert "amending RCW 49.17.060; adding a new section to chapter 49.17 RCW; adding a new section to chapter 17.21 RCW; and declaring an emergency."